Truck aero improvements - Page 2 - Fuelly Forums

Click here to see important news regarding the aCar App

Reply
 
Thread Tools Display Modes
 
Old 05-15-2007, 07:16 PM   #11
Registered Member
 
Snax's Avatar
 
Join Date: Mar 2007
Posts: 758
Country: United States
I'll just say that according to the stock mileage computer on ours (which seems to be within a tenth or two on accuracy per tank), the biggest draw on our fuel is the time we spend idling at lights and drive-thrus. On the ten mile round trip to drop my kids off at a school, waiting 5 minutes at the Starbuck drive-thru on the way back loses us about 10% of our economy. Frequent stop and go drags it down even further.

Even if we improved our aerodynamics substantially, the impact of city driving would still drastically reduce the benefit.
__________________

__________________
LiberalImage.com

I think, therefore I doubt.
Snax is offline   Reply With Quote
Old 05-16-2007, 07:22 AM   #12
Registered Member
 
Join Date: Oct 2005
Posts: 682
Country: United States
Quote:
Originally Posted by beatr911 View Post
Hey sludgy is there a way to alter the timing on diesels that improves FE but reduces power? Seems with all the high fuel prices someone must have a chip that works by now.
I tried a Mileage Miser chip from Granatelli Motorsports. The mileage got worse, and the motor ran like a bag of ****. I took it out. Not into chipping the truck now.
__________________

__________________
Capitalism: The cream rises. Socialism: The scum rises.
Sludgy is offline   Reply With Quote
Old 05-16-2007, 11:27 AM   #13
Registered Member
 
brucepick's Avatar
 
Join Date: Feb 2007
Posts: 722
Country: United States
Location: Connecticut
I like the underbody cover sheet plan. Assuming you spend significant time at 50 mph or better.

Somebody posted that their biggest fuel killer was idling at lights and drive-thrus. True that idling kills mpg. However for your highway driving, air drag is your biggest killer. On a decent hill if the aero is decent, the vehicle will accelerate. Or at least coast without losing speed. If drag is bad enough this won't happen, you need lots of engine output to overcome what you lose to drag. Of course on level ground what you lose is the same. it's just that on a hill you see it easier - you lose speed when you should be gaining it from the hill.

My Volvo is also about as aerodynamic as a brick and I'm doing what I can bit by bit. The advantage with a truck is that there's tons of room underneath to build what you need. Lots of ground clearance; you probably don't need all of it so whatever you lose to your new underbody treatment is OK.
__________________
Currently getting +/- 50 mpg in fall weather. EPA is 31/39 so not too shabby. WAI, fuel cutoff switch, full belly pan, smooth wheel covers.

Now driving '97 Civic HX; tires ~ 50 psi. '89 Volvo 240 = semi-retired.
brucepick is offline   Reply With Quote
Old 05-16-2007, 07:39 PM   #14
Registered Member
 
kickflipjr's Avatar
 
Join Date: Sep 2005
Posts: 933
Country: United States
Quote:
Originally Posted by theclencher View Post
Not likely. Trucks have Cd above .4 so unless you go all Phil Knox on it I don't think it'll really help a whole bunch.

It case you didn't know who phil knox is. here is his truck:

__________________
2008 EPA adjusted:


Distance traveled by bicycle in 2007= 1,830ish miles
Average commute speed=25mph (yes, that's in a car)
kickflipjr is offline   Reply With Quote
Old 05-16-2007, 08:46 PM   #15
Supporting Member
 
lovemysan's Avatar
 
Join Date: Jun 2006
Posts: 595
Country: United States
Well, the problem with a belly pan on a truck especially a 4wd is there not practical. My belly pan took a beating just from ice alone. You also must consider that both axle's must have room to move up and down. Also factor the the frames flex under heavy loads. I'd also be worried about exhaust heat. Remember this truck has 325hp diesel engine, its going to produce a lot heat, towing. I'd be worried about melting something.
__________________
02 Saturn SL
5 speed
for pics click the link below

https://s75.photobucket.com/albums/i3...emysan/saturn/

[SIGPIC][/SIGPIC]
"for best mileage swap in a d15z1"
lovemysan is offline   Reply With Quote
Old 05-17-2007, 06:38 AM   #16
Registered Member
 
Join Date: Apr 2006
Posts: 228
Country: United States
I agree with the clencher, those high performance trucks are rediculous. Trucks do make sense for hauling heavy loads...and if you do this frequently or for a living, an underbody pan or a boat tail would make a lot of sense. But in the long run, if you are not hauling things all the time, a nice beater honda or toyota would be good to have for all other trips when not hauling. The best way to save gas with a truck is to only start it up when hauling a trailer or over 1,000lbs.

I know this is an obvious one but: Do you have a grille block? that might help the truck warm up faster and get better mpg on the hwy...remember to remove it when towing on hot days!
GasSavers_James is offline   Reply With Quote
Old 05-17-2007, 07:10 AM   #17
Registered Member
 
Join Date: Oct 2005
Posts: 682
Country: United States
Quote:
Originally Posted by James View Post
I agree with the clencher, those high performance trucks are rediculous. Trucks do make sense for hauling heavy loads...and if you do this frequently or for a living, an underbody pan or a boat tail would make a lot of sense. But in the long run, if you are not hauling things all the time, a nice beater honda or toyota would be good to have for all other trips when not hauling. The best way to save gas with a truck is to only start it up when hauling a trailer or over 1,000lbs.

I know this is an obvious one but: Do you have a grille block? that might help the truck warm up faster and get better mpg on the hwy...remember to remove it when towing on hot days!
Yes, I have a nice canvas grille block.
__________________
Capitalism: The cream rises. Socialism: The scum rises.
Sludgy is offline   Reply With Quote
Old 05-17-2007, 02:10 PM   #18
Registered Member
 
Join Date: Mar 2007
Posts: 1,138
Country: United States
He's not trying to make the truck something that it is not. He still wants for it to be a truck. He just wants for it to be the best possible truck it can be.

Like for me. I have the Element because I want an Element. I could have a CRV, but I don't want one. I could have an Accord, but I don't want one. I want an Element. But, I still want for it to get the best mileage it can get without losing the utility(value) that I derive from it.
__________________
Bill in Houston is offline   Reply With Quote
Old 05-17-2007, 03:16 PM   #19
Registered Member
 
omgwtfbyobbq's Avatar
 
Join Date: Jul 2006
Posts: 1,516
Country: United States
What? I need a 6000lb truck to get milk from the store!
__________________
Quote:
Originally Posted by FormulaTwo
I think if i could get that type of FE i would have no problem driving a dildo shaped car.
omgwtfbyobbq is offline   Reply With Quote
Old 05-17-2007, 03:48 PM   #20
Supporting Member
 
lovemysan's Avatar
 
Join Date: Jun 2006
Posts: 595
Country: United States
Quote:
Originally Posted by James View Post
I agree with the clencher, those high performance trucks are rediculous. Trucks do make sense for hauling heavy loads...and if you do this frequently or for a living, an underbody pan or a boat tail would make a lot of sense. But in the long run, if you are not hauling things all the time, a nice beater honda or toyota would be good to have for all other trips when not hauling. The best way to save gas with a truck is to only start it up when hauling a trailer or over 1,000lbs.

I know this is an obvious one but: Do you have a grille block? that might help the truck warm up faster and get better mpg on the hwy...remember to remove it when towing on hot days!
Ooh my favorite vehicle ever was my 91 dodge, cummins powered. I cranked the pump and did some minor mods. It was actually fun to drive. It ran a 16.2 spinning badly through second. Easy 15.8s with a locker. Smoked like a frieght train for tailgater removing.
__________________

__________________
02 Saturn SL
5 speed
for pics click the link below

https://s75.photobucket.com/albums/i3...emysan/saturn/

[SIGPIC][/SIGPIC]
"for best mileage swap in a d15z1"
lovemysan is offline   Reply With Quote
Reply

Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are Off
Pingbacks are Off
Refbacks are Off


Similar Threads
Thread Thread Starter Forum Replies Last Post
Partial fuel-up - when do you reset your trip odometer? johnclayton Fuelly Web Support and Community News 2 07-30-2009 09:16 PM
Feature Request: City vs Highway jethrographic Fuelly Web Support and Community News 1 08-08-2008 09:43 AM
FREE D15B7 almost complete motor UfoTofU For Sale 7 02-20-2007 05:37 PM
How did you first find Gassavers.org? kickflipjr General Discussion (Off-Topic) 17 05-24-2006 07:28 PM
If you're jealous of Matt, (or have 56k) don't look here. bagpipe goatee General Discussion (Off-Topic) 8 11-15-2005 06:24 PM

» Fuelly iOS Apps
Powered by vBadvanced CMPS v3.2.3


All times are GMT -8. The time now is 12:45 AM.


Powered by vBulletin® Version 3.8.8 Beta 1
Copyright ©2000 - 2024, vBulletin Solutions, Inc.